Reliability, what owners report, and what it costs to keep.
AVOIR's read: the numbers are mixed and the complaint record is worth reading before you commit.
Owners have filed 91 complaints with NHTSA about the 2005 Saturn Relay, and it carries 3 recalls. These are owner allegations rather than confirmed defects, but the pattern of what people complain about is the most useful signal a used buyer has.
| Area | Complaints | Share |
|---|---|---|
| Service brakes | 14 | 15% |
| Electrical system | 10 | 11% |
| Structure | 9 | 10% |
| Latches/locks/linkages | 5 | 5% |
| Service brakes | 4 | 4% |
| Fuel system | 4 | 4% |
| Service brakes | 4 | 4% |
| Electrical system | 2 | 2% |
| Suspension | 2 | 2% |
| Traction control system | 2 | 2% |
Verbatim from NHTSA complaint records, trimmed for length.
EXACT SAME ISSUE AS DESCRIBED IN APRIL 2014 GM RECALL 14063. SUDDEN LOSS OF ELECTRICAL POWER WHILE DRIVING CAUSING THE ENGINE TO SHUT OFF. UNPREDICTABLE VERY DANGEROUS. SEEMS TO BE THE IGNITION SWITCH. OTHER SATURNS ARE
NHTSA complaint: Electrical system
THE ANTI-LOCK BRAKE SYSTEM WARNING LIGHT AND TRACTION CONTROL SYSTEM (TCS) WARNING LIGHT CONTINUE TO LIGHT UP AND STAYS ON I HAVE SEEN SIMILAR COMPLAINTS ON VARIOUS CHAT SESSIONS.
NHTSA complaint: Unknown or other
TL* THE CONTACT OWNS A 2005 SATURN RELAY. WHILE OPERATING THE VEHICLE, THE SPEED SENSOR AND TRACTION CONTROL SENSOR LIGHTS ILLUMINATED AND THE BRAKING DISTANCE INCREASED WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WA
NHTSA complaint: Steering
THE FIRST TIME I WAS PARKED AND THE VAN WOULD NOT START. I WAS TOLD IT MIGHT BE THE FUEL PUMP. I HAD THE VAN TOW TO A SERVICE CENTER. THEY SAID IT WAS THE FUEL RELAY. I PAID TO HAVE THE FUEL RELAY REPLACED. A FEW DAYS LA
NHTSA complaint: Electrical system
WHEN I DRIVE AT NIGHT I HAVE TO TURN MY HEADLIGHTS OFF TO USE MY TURN SIGNALS. I HAVE NOTICED THAT THE TURN SIGNAL ON THE DRIVER'S SIDE OF THE 2005 SATURN RELAY WILL NOT WORK UNLESS THE HEADLIGHTS ARE TURNED OFF. I HAVE
NHTSA complaint: Electrical system
DRIVING AROUND 10 MPH, CAR DIED. TOOK IT TO THE SHOP AND THEY SAID IT WAS THE IGNITION SWITCH. LOOKED ON GM WEBSITE AND THERE IS A RECALL FOR THIS SAME PROBLEM, HOWEVER NOT FOR THE RELAY. I BELIEVE THERE SHOULD BE A R
NHTSA complaint: Electrical system
REPEATED PROBLEMS WITH ABS & T/C WARNING LIGHTS, BRAKES SEIZED UP WAS UNABLE TO MOVE VAN HAD IT TOWED TO A SHOP, T/C ENGAGES WITHOUT ANY ADVERSE WEATHER OR ROAD CONDITIONS. I HAVE SPENT OVER $2000 TRYING TO REPAIR THE P
NHTSA complaint: Service brakes
TL* THE CONTACT OWNS A 2005 SATURN RELAY. WHILE DRIVING APPROXIMATELY 40 MPH, THE ABS WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE ABS HUB SENSOR WAS REPLACED. IN A
NHTSA complaint: Service brakes
NHTSA lists 3 recall campaigns for the 2005 Saturn Relay. Recalls are free to have fixed at a franchised dealer regardless of who owns the car now, but only if they were never done, so check the VIN of the specific car rather than trusting the model.
ON CERTAIN MINIVANS, THE OUTBOARD RELEASE HANDLE ON THE IMPACT-SIDE SECOND-ROW BUCKET SEAT MAY BE ACTUATED AND THE REAR LATCHES MAY UNLATCH EARLY IN A SIDE IMPACT CRASH. THIS WAS DISCOVERED IN A SIDE IMPACT TEST RUN BY GM, UNDER CONDITIONS SIMILAR TO NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) SIDE
Risk: IF THE REAR LATCHES OF THE SEAT RELEASE EARLY IN A SEVERE SIDE IMPACT, THE FRONT OUTBOARD LATCH MAY DISENGAGE AND INCREASE THE POTENTIAL FOR INJURY TO THE OCCUPANT OF THE SEAT.
Fix: DEALERS WILL REMOVE THE SEAT LATCH RELEASE HANDLE AND INSTALL A BLACK PLASTIC CAP OVER THE EXPOSED METAL STUD TO ELIMINATE THE SIDE IMPACT SAFETY CONCERN FREE OF CHARGE. THE RECALL BEGAN ON APRIL 5, 2
DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN
Risk: A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
Fix: DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT D
CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' TO MEET THE STANDARD, THE VEHICLE MUST NOT MOVE FOR FIVE MINUTES WHEN STOPPED ON A STEEP HILL WITH THE PARKING BRAKE APPLIED AND THE VEHICLE IN NEUTRAL
Risk: WHEN THE PARKING BRAKE IS RELEASED, THE DRIVER MAY NOTICE UNINTENDED BRAKING WHEN ACCELERATING, DECELERATING, OR COASTING, AND A NOISE COMING FROM THE REAR OF THE VEHICLE. UNINTENDED VEHICLE MOVEMENT
Fix: DEALERS WILL INSPECT FOR PARKING BRAKE LEVER SLIPPAGE AT EACH REAR BRAKE CALIPER AND REPLACE THE CALIPER IF LEVER SLIPPAGE IS IDENTIFIED. THE RECALL BEGAN ON NOVEMBER 14, 2005. OWNERS MAY CONTACT BU
| Reliability raw | 79 | good |
|---|---|---|
| Longevity est. | 77 | good |
| Maintenance | 68 | good |
| Depreciation | 65 | good |
| Performance | 67 | good |
| Efficiency | 33 | below average |
Percentile ranks against other minivans & vans in the catalog.
What stands behind each score for this car:
Owners have filed 91 complaints with NHTSA for this model-year, and service brakes is the most reported area with 14 of them (15%). There are 3 recalls on record. Check any specific car against its VIN before buying.
AVOIR scores its reliability 79/100 (good) from NHTSA recall campaigns and complaint density. That figure is a raw complaint count, not yet adjusted for sales volume, so a high-volume model scores worse than it deserves.
AVOIR scores its longevity 77/100, but that figure is an estimate built from the powertrain and the brand's record, not a measurement. A 2005 car has no 200,000-mile population to observe yet, so treat it as a prior rather than evidence.
AVOIR's read: be careful, because the numbers are mixed and the complaint record is worth reading before you commit. Its overall ownership score is 69/100. Condition, mileage and service history still matter more than any score, so get a pre-purchase inspection on the specific car.
Sources: NHTSA recalls and complaints, EPA fuel economy, IIHS awards, and live market listings. A score describes a model-year, not the individual car in front of you. Get a pre-purchase inspection.