Reliability, what owners report, and what it costs to keep.
AVOIR's read: the numbers are mixed and the complaint record is worth reading before you commit.
Owners have filed 196 complaints with NHTSA about the 2005 Chevrolet Uplander, and it carries 4 recalls. These are owner allegations rather than confirmed defects, but the pattern of what people complain about is the most useful signal a used buyer has.
| Area | Complaints | Share |
|---|---|---|
| Structure | 28 | 14% |
| Latches/locks/linkages | 28 | 14% |
| Electrical system | 21 | 11% |
| Service brakes | 7 | 4% |
| Fuel system | 6 | 3% |
| Seat belts | 5 | 3% |
| Electrical system | 5 | 3% |
| Engine and engine cooling | 4 | 2% |
| Power train | 4 | 2% |
| Electrical system | 4 | 2% |
Verbatim from NHTSA complaint records, trimmed for length.
The contact owns a 2005 Chevrolet Uplander. The contact stated that while driving at undisclosed speeds, the vehicle was drifting and would not drive in a straight line. The vehicle was taken to the local mechanic who pe
NHTSA complaint: Wheels
MY VAN HESITATES BETWEEN 2 AND 3 RPM'S. ESPECIALLY GOING UP A HILL, THE ENGINE LIGHT WILL BLINK FOR A FEW SECONDS. THEN ENGINE LIGHT CONTINUES TO STAY ON..THE DRIVERS SIDE DOOR IS MALFUNCTIONING.. WHEEL BEARING IN THE
NHTSA complaint: Exterior lighting
THE DRIVER SIDE SEAT BELT DOES NOT BUCKLE INTO THE LATCH. THERE'S A METAL PIECE INSIDE THE LATCH BLOCKING IT FROM SLIDING IN AND SNAPPING IN. THIS STARTED HAPPENING A FEW DAYS AGO, PREVENTING ME FROM DRIVING THE VAN SINC
NHTSA complaint: Seat belts
WHILE DRIVING DOWN I-75 IN MICHIGAN DOING ~75MPH, I FEEL A SHARP TUG THEN A SWAY. WE TOOK THE VEHICLE HOME AND INSPECTED IT. THE WELDS ON THE BODY TO THE ATTACHING POINT OF THE REAR AXLE HAD BROKEN AND THE REAR END OF TH
NHTSA complaint: Suspension
DRIVING THE VEHICLE ALONG THE INTERSTATE AT 65 MPH AT NIGHT, THE IGNITION SWITCH RUN POSITION ROTATED TO OFF AND THE ENGINE AND ALL HEADLIGHTS, DASH, ETC, SHUTDOWN ALONG WITH THE POWER STEERING AND POWER BRAKES. THE INC
NHTSA complaint: Electrical system
I WAS HEARING ABOUT THE RECENT RECALL ACTIONS ABOUT CHEVY SUVS WITH WIPER BLADES. BUT, I HAVE HAD AN ISSUE WHERE MY WIPER WOULD STOP IN THE MIDDLE OF THE WINDSHIELD. MY VEHICLE WAS NOT IN THE RECALL, BUT, JUST MADE ME
NHTSA complaint: Visibility/wiper
THE BACK REAR HATCH WHEN I LIFTED DROPPED! I GOT MY HANDS UP FAST ENOUGH TO STOP IT AND WAS NOT INJURED THOUGH
NHTSA complaint: Structure
THE CHASSIS HAS A SERIOUS RUST ISSUE AS I'VE NEVER SEEN BEFORE. THE RUST ISSUE IS ONE THAT YOU WOULD NOT EVEN SEE ON A 60 YEAR OLD CAR. IT CAUSED THE REAR WHEEL AND ALL OF ITS COMPONENTS TO BREAK FREE. I DO HAVE PICTURES
NHTSA complaint: Structure
NHTSA lists 4 recall campaigns for the 2005 Chevrolet Uplander. Recalls are free to have fixed at a franchised dealer regardless of who owns the car now, but only if they were never done, so check the VIN of the specific car rather than trusting the model.
DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN
Risk: A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
Fix: DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT D
ON CERTAIN MINIVANS, THE OUTBOARD RELEASE HANDLE ON THE IMPACT-SIDE SECOND-ROW BUCKET SEAT MAY BE ACTUATED AND THE REAR LATCHES MAY UNLATCH EARLY IN A SIDE IMPACT CRASH. THIS WAS DISCOVERED IN A SIDE IMPACT TEST RUN BY GM, UNDER CONDITIONS SIMILAR TO NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) SIDE
Risk: IF THE REAR LATCHES OF THE SEAT RELEASE EARLY IN A SEVERE SIDE IMPACT, THE FRONT OUTBOARD LATCH MAY DISENGAGE AND INCREASE THE POTENTIAL FOR INJURY TO THE OCCUPANT OF THE SEAT.
Fix: DEALERS WILL REMOVE THE SEAT LATCH RELEASE HANDLE AND INSTALL A BLACK PLASTIC CAP OVER THE EXPOSED METAL STUD TO ELIMINATE THE SIDE IMPACT SAFETY CONCERN FREE OF CHARGE. THE RECALL BEGAN ON APRIL 5, 2
THE BRAUN CORPORATION HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2005-2008 GENERAL MOTORS MOBILITY CONVERSION, HANDICAPPED ACCESSIBLE LOW FLOOR MINIVANS. DURING CONVERSION, THE DRIVER OR PASSENGER SIDE TRAILING ARM MODIFICATION MAY NOT HAVE BEEN ADEQUATELY WELDED.
Risk: A SQUEAKING OR CLUNKING NOISE MAY DEVELOP. THE TRAILING ARM BUSHINGS MAY PREMATURELY WEAR AND THE TRAILING ARM MAY FRACTURE OR SEPARATE, ALLOWING THE REAR AXLE TO BECOME PARTIALLY SEPARATED FROM THE
Fix: DEALERS WILL INSPECT AND WILL HAVE A SUPPLY OF RETROFIT PARTS AVAILABLE TO REMEDY THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 4, 2010. OWNERS MAY CONTACT BRAUN AT 1-800-488-0359.
CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' TO MEET THE STANDARD, THE VEHICLE MUST NOT MOVE FOR FIVE MINUTES WHEN STOPPED ON A STEEP HILL WITH THE PARKING BRAKE APPLIED AND THE VEHICLE IN NEUTRAL
Risk: WHEN THE PARKING BRAKE IS RELEASED, THE DRIVER MAY NOTICE UNINTENDED BRAKING WHEN ACCELERATING, DECELERATING, OR COASTING, AND A NOISE COMING FROM THE REAR OF THE VEHICLE. UNINTENDED VEHICLE MOVEMENT
Fix: DEALERS WILL INSPECT FOR PARKING BRAKE LEVER SLIPPAGE AT EACH REAR BRAKE CALIPER AND REPLACE THE CALIPER IF LEVER SLIPPAGE IS IDENTIFIED. THE RECALL BEGAN ON NOVEMBER 14, 2005. OWNERS MAY CONTACT BU
| Reliability raw | 63 | average |
|---|---|---|
| Longevity est. | 70 | good |
| Maintenance | 68 | good |
| Depreciation | 62 | average |
| Performance | 67 | good |
| Efficiency | 33 | below average |
Percentile ranks against other minivans & vans in the catalog.
What stands behind each score for this car:
Owners have filed 196 complaints with NHTSA for this model-year, and structure is the most reported area with 28 of them (14%). There are 4 recalls on record. Check any specific car against its VIN before buying.
AVOIR scores its reliability 63/100 (average) from NHTSA recall campaigns and complaint density. That figure is a raw complaint count, not yet adjusted for sales volume, so a high-volume model scores worse than it deserves.
AVOIR scores its longevity 70/100, but that figure is an estimate built from the powertrain and the brand's record, not a measurement. A 2005 car has no 200,000-mile population to observe yet, so treat it as a prior rather than evidence.
AVOIR's read: be careful, because the numbers are mixed and the complaint record is worth reading before you commit. Its overall ownership score is 63/100. Condition, mileage and service history still matter more than any score, so get a pre-purchase inspection on the specific car.
Sources: NHTSA recalls and complaints, EPA fuel economy, IIHS awards, and live market listings. A score describes a model-year, not the individual car in front of you. Get a pre-purchase inspection.