Reliability, what owners report, and what it costs to keep.
AVOIR's read: a solid ownership case with specific caveats below.
Owners have filed 36 complaints with NHTSA about the 2003 Suzuki Aerio, and it carries 2 recalls. These are owner allegations rather than confirmed defects, but the pattern of what people complain about is the most useful signal a used buyer has.
| Area | Complaints | Share |
|---|---|---|
| Power train | 11 | 31% |
| Wheels | 6 | 17% |
| Tires | 2 | 6% |
| Engine and engine cooling | 2 | 6% |
| Service brakes | 2 | 6% |
| Engine | 1 | 3% |
| Latches/locks/linkages | 1 | 3% |
| Unknown or other | 1 | 3% |
| Vehicle speed control | 1 | 3% |
| Steering | 1 | 3% |
Verbatim from NHTSA complaint records, trimmed for length.
STARTED THE CAR TO WARM IT UP, AND SMOKE CAME OUT OF DASH BOARD, MAKING GLASS WHERE SPEEDOMETER IS SMOKEY AND IT STILL IS. SMELT LIKE WIRE BURNING AND SHUT IT OFF IMMEDIATELY. WHEN CHECKED ON, A WIRE INSULATION HAD BUR
NHTSA complaint: Engine
TL* THE CONTACT OWNS A 2003 SUZUKI AERIO SX WAGON. THE CONTACT STATED THAT THE MANUAL TRANSMISSION DISLODGED FROM THE FIFTH GEAR WHILE DRIVING 55 MPH. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INF
NHTSA complaint: Power train
TL*THE CONTACT OWNS A 2003 SUZUKI AERIO SX. THE CONTACT STATED THAT THE DOOR HANDLE BROKE WHILE ATTEMPTING TO OPEN IT. THE DEALER AND MANUFACTURER WERE NOTIFIED OF THE DEFECT. THE DOOR HANDLE WAS NOT REPAIRED. THE FAI
NHTSA complaint: Latches/locks/linkages
I HAVE HAD PROBLEMS WITH MY CAR FOR ALMOST 2 MONTHS AND IT SEEMS IT NEVER ENDS. SERIOUS POWER STEERING PROBLEMS WHICH CAUSES A LOT OF INCONVENIENCES FOR A SINGLE MOTHER LIKE ME, TAKEN TO SOME SHOPS, MONEY WASTED ON NOTHI
NHTSA complaint: Unknown or other
THE REASON IS THAT I BOUGHT ONE USED GOOD YEAR TIRE BUT I JUST RUN ON HIGH WAY FOR FEW MILES ONLY IT WAS SERIOUSLY FLAT ON LAST SATURDAY (MAY 9, 2009). I DID NOT KNOW WHY AN INFERIOR TIRE WOULD BE SOLD IN THE STORE, WHEN
NHTSA complaint: Tires
2003 SUZUKI AERIO CV JOINT KEEPS COMING OUT DUE TO SNAP RING IN REAR END,CAR IS UNDER WARRANTY. CAR DEALER WILL NOT HONOR WARRANTY,SAYS REAR AXLE IS A AFTER MARKET PART, THIS IS NOT TRUE,WHY WOULD WE HAVE CAR WORKED ON W
NHTSA complaint: Power train
CRACKING AND BENDING OF RIM WHERE THE TIRE BEAD SEALS,HAVE HAD TO REPLACE THREE DIFFERENT RIMS IN THE LAST TWO AND A HALF YEARS. *TR
NHTSA complaint: Wheels
I AM WRITING IN REFERENCE TO TIRE DEBRIS BEING LEFT IN THE MIDDLE OF NEW YORK'S HIGHWAYS. THESE SITUATIONS CREATE HAZARDOUS ROAD CONDITIONS AND SHOULD BE HANDLED BY THE LOCAL GOVERNMENTAL AGENCIES. TODAY, I WAS TRAVELING
NHTSA complaint: Tires
NHTSA lists 2 recall campaigns for the 2003 Suzuki Aerio. Recalls are free to have fixed at a franchised dealer regardless of who owns the car now, but only if they were never done, so check the VIN of the specific car rather than trusting the model.
CERTAIN PASSENGER (111 MY 2002 ESTEEM, 777 MY 2002 AERIO, 2,368 MY 2003 AERIO) AND SPORT UTILITY (324 MY 2002 GRAND VITARA, 274 MY 2003 GRAND VITARA, 684 MY 2002 GRAND VITARA XL-7, AND 781 MY 2003 GRAND VITARA XL-7) VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDA
Risk: IF THE WINDSHIELD IS NOT PROPERLY SECURED, IT MAY SEPARATE FROM THE VEHICLE DURING A CRASH WHICH COULD RESULT IN THE EJECTION OF UNBELTED OCCUPANTS, INCREASING THE RISK OF SEVERE INJURY OR DEATH.
Fix: DEALERS WILL INSPECT THESE VEHICLES. VEHICLES THAT ARE FOUND TO HAVE INSUFFICIENT PAINT ADHESION WILL EITHER HAVE THE PROBLEM REMEDIED BY REPAINTING, OR WILL BE REPLACED, OR REPURCHASED AND DESTROYED
ON CERTAIN VEHICLES EQUIPPED WITH 5-SPEED MANUAL TRANSMISSIONS, DUE TO IMPROPER SHAPE OF THE CLIP, THE RETAINING CLIP THAT KEEPS THE GEAR SHIFT CABLE ATTACHED TO THE GEAR SHIFT LEVER CAN CONTACT THE GEAR SHIFT LEVER HOUSING IF EXCESSIVE LATERAL FORCE IS APPLIED WHEN SHIFTING TO FIRST GEAR.
Risk: REPEATED SHIFTING IN THIS MANNER CAN EVENTUALLY CAUSE THE RETAINING CLIP TO BREAK. IF THE RETAINING CLIP BREAKS, THE SHIFT CABLE CAN BECOME DISCONNECTED FROM THE SHIFT LEVER, RESULTING IN LOSS OF THE
Fix: DEALERS WILL REPLACE THE GEAR SHIFT CABLE RETAINING CLIP WITH A CLIP THAT HAS A DIFFERENT SHAPE. THE RECALL BEGAN ON AUGUST 13, 2007. OWNERS MAY CONTACT AMERICAN SUZUKI AT 1-800-934-0934.
| Reliability raw | 87 | excellent |
|---|---|---|
| Longevity est. | 81 | excellent |
| Maintenance | 90 | excellent |
| Depreciation | 60 | average |
| Performance | 45 | below average |
| Efficiency | 46 | below average |
Percentile ranks against other compact cars in the catalog.
What stands behind each score for this car:
Owners have filed 36 complaints with NHTSA for this model-year, and power train is the most reported area with 11 of them (31%). There are 2 recalls on record. Check any specific car against its VIN before buying.
AVOIR scores its reliability 87/100 (excellent) from NHTSA recall campaigns and complaint density. That figure is a raw complaint count, not yet adjusted for sales volume, so a high-volume model scores worse than it deserves.
AVOIR scores its longevity 81/100, but that figure is an estimate built from the powertrain and the brand's record, not a measurement. A 2003 car has no 200,000-mile population to observe yet, so treat it as a prior rather than evidence.
AVOIR's read: worth a look, because a solid ownership case with specific caveats below. Its overall ownership score is 74/100. Condition, mileage and service history still matter more than any score, so get a pre-purchase inspection on the specific car.
Sources: NHTSA recalls and complaints, EPA fuel economy, IIHS awards, and live market listings. A score describes a model-year, not the individual car in front of you. Get a pre-purchase inspection.