Reliability, what owners report, and what it costs to keep.
AVOIR's read: a solid ownership case with specific caveats below.
Owners have filed 49 complaints with NHTSA about the 2003 Saab 9-5, and it carries 4 recalls. These are owner allegations rather than confirmed defects, but the pattern of what people complain about is the most useful signal a used buyer has.
| Area | Complaints | Share |
|---|---|---|
| Electrical system | 15 | 31% |
| Engine and engine cooling | 5 | 10% |
| Tires | 4 | 8% |
| Suspension | 3 | 6% |
| Electrical system | 2 | 4% |
| Fuel system | 2 | 4% |
| Fuel/propulsion system | 1 | 2% |
| Power train | 1 | 2% |
| Electrical system | 1 | 2% |
| Seat belts | 1 | 2% |
Verbatim from NHTSA complaint records, trimmed for length.
I HAD TO REPLACE FUEL PUMP 3 TIMES IN 4 YEARS. IT SMELLED LIKE FUEL IN MY CAR.
NHTSA complaint: Fuel/propulsion system
TL* THE CONTACT OWNS A 1993 BUICK REGAL. THE CONTACT STATED THAT ALL DOOR LOCKS WOULD BECOME STUCK WHEN ACTIVATED BY THE ELECTRONIC DOOR LOCK SYSTEM. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NO
NHTSA complaint: Electrical system
AFTER DRIVING MY CAR TO MY DESTINATION, I PUT THE CAR IN PARK BUT THE CAR WON'T STAY IN PARK. THE CAR POPS OUT OF PARK INTO REVERSE, THEN IT WON'T START WHEN I GET BACK INTO MY CAR. *TR
NHTSA complaint: Power train
TL* THE CONTACTS OWNS A 2003 SAAB 9-5. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS, THE CHECK ENGINE WARNING LIGHT ILLUMINATED AND THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO A INDEPENDENT MECHANIC WHERE THE T
NHTSA complaint: Electrical system
I WAS DRIVING THE CAR WHEN SUDDENLY THE CAR WHEN DEAD WHILE I WAS DRIVING IT.I WAS LUCKY THAT I WAS ABLE TO RESTART IT AND THERE WAS A GAS STATION RIGHT NEAR BY. IT DID NOT START UP NORMALLY AND WAS VERY SLUGGISH. I WAS
NHTSA complaint: Electrical system
TL* THE CONTACT OWNS A 2003 SAAB 9-5. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE VEHICLE STALLED. THE CONTACT STATED THAT THE STEERING WHEEL AND THE BRAKES SEIZED AS THE ENGINE STALLED. THE CONTACT WAS ABLE TO STO
NHTSA complaint: Electrical system
THE HORN OFTEN FAILS TO WORK WHEN THE STEERING WHEEL MOUNTED AIRBAG COVER IS PRESSED. THIS IS AN ONGOING, UNRESOLVED PROBLEM. A DEALER REPLACED A PART UNDER WARRANTY BUT THAT DID NOT FIX THE PROBLEM. I HAVE SEEN SEVERAL
NHTSA complaint: Electrical system
THE FRONT SEATBELTS FRAY NEAR WHERE THE BUCKLE SECURES THE BELT WHEN IN USE. THE SEATBELT WAS REPLACED WITH OEM PARTS FOR THIS REASON. THE NEW BELT HAS FRAYED AGAIN OVER A SHORT PERIOD OF TIME. OTHERS REPORT SIMILAR PROB
NHTSA complaint: Seat belts
NHTSA lists 4 recall campaigns for the 2003 Saab 9-5. Recalls are free to have fixed at a franchised dealer regardless of who owns the car now, but only if they were never done, so check the VIN of the specific car rather than trusting the model.
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP RETAINING TABS HOLDING THE FUEL LINES WERE DAMAGED DURING PRODUCTION.
Risk: OVER TIME, THIS COULD CAUSE THE FUEL LINES TO LOOSEN FROM THE PUMP RESULTING IN FUEL LEAKAGE. IF AN IGNITION SOURCE WERE PRESENT, THE FUEL MAY IGNITE RESULTING IN A VEHICLE FIRE.
Fix: DEALERS WILL DEVELOP A SECURING BRACKET THAT WILL SECURE THE FUEL LINES TO THE FUEL PUMP EVEN IF THE PLASTIC RETAINING TABS SHOULD BREAK. THE RECALL BEGAN ON JUNE 13, 2007. THIS IS AN EXPANSION OF
ON CERTAIN PASSENGER VEHICLES, IF AN OWNER CHANGES THEIR WHEELS/TIRES BETWEEN SUMMER AND WINTER USING A STEEL WHEEL IN THE WINTER AND AN ALLOY WHEEL IN THE SUMMER, IT IS POSSIBLE FOR RUST AND CONTAMINATION TO BUILD UP ON THE WHEEL HUB DURING THE STEEL WHEEL USAGE. IF THIS OCCURS AND THE CONTAMINATI
Risk: THESE FRACTURES WOULD RESULT IN WHEEL BOLT BREAKAGE, ALLOWING THE WHEEL TO DETACH FROM THE WHEEL HUB, INCREASING THE RISK OF A CRASH.
Fix: OWNERS WILL BE CONTACTED BY MAIL AND ASKED WHETHER THEY CHANGE BETWEEN STEEL AND ALLOY WHEELS. IF THEY DO ENGAGE IN THIS PRACTICE, THEY WILL BE INSTRUCTED TO BRING THEIR CARS TO AN AUTHORIZED DEALER.
SAAB IS RECALLING 57,389 MY 2002-2008 9-5 SERIES VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING COMPLIANCE TESTING, ONE OF THE UPPER INTERIOR OCCUPANT PROTECTION TEST POINTS EXCEEDED THE STANDARD
Risk: IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
Fix: DEALERS WILL INSTALL A-PILLAR TRIM WITH IMPROVED ENERGY-ABSORBING CAPABILITY FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 25, 2008. OWNERS MAY CONTACT SAAB AT 1-800-955-9007.
CERTAIN PASSENGER VEHICLES EQUIPPED WITH B308 6-CYLINDER GASOLINE ENGINES MAY EXPERIENCE OVERHEATING AND BURNOUT OF THE ISOLATED GATED BIPOLAR TRANSISTOR (IGBT) WITHIN THE IGNITION DISCHARGE MODULE (IDM) DUE TO INCREASED SUSCEPTIBILITY TO ELECTRICAL LOADS.
Risk: OVERHEATING OF THE IGBT OCCURS MOST OFTEN AT ENGINE START-UP, BUT IT MAY ALSO OCCUR WHILE THE ENGINE IS RUNNING. ENGINE STALLING MAY OCCUR, WHICH COULD RESULT IN A CRASH.
Fix: DEALERS WILL INSPECT TO SEE WHAT VERSION IDM IS IN THE VEHICLE AND REPLACE THE IDM IF IT IS A VERSION BUILT PRIOR TO JANUARY 2003. THE RECALL IS EXPECTED TO BEGIN DURING DECEMBER 2005. OWNERS MAY CO
| Reliability raw | 85 | excellent |
|---|---|---|
| Longevity est. | 76 | good |
| Maintenance | 79 | good |
| Depreciation | 60 | average |
| Performance | 55 | average |
| Efficiency | 40 | below average |
Percentile ranks against other midsize & large cars in the catalog.
What stands behind each score for this car:
Owners have filed 49 complaints with NHTSA for this model-year, and electrical system is the most reported area with 15 of them (31%). There are 4 recalls on record. Check any specific car against its VIN before buying.
AVOIR scores its reliability 85/100 (excellent) from NHTSA recall campaigns and complaint density. That figure is a raw complaint count, not yet adjusted for sales volume, so a high-volume model scores worse than it deserves.
AVOIR scores its longevity 76/100, but that figure is an estimate built from the powertrain and the brand's record, not a measurement. A 2003 car has no 200,000-mile population to observe yet, so treat it as a prior rather than evidence.
AVOIR's read: worth a look, because a solid ownership case with specific caveats below. Its overall ownership score is 71/100. Condition, mileage and service history still matter more than any score, so get a pre-purchase inspection on the specific car.
Sources: NHTSA recalls and complaints, EPA fuel economy, IIHS awards, and live market listings. A score describes a model-year, not the individual car in front of you. Get a pre-purchase inspection.