Reliability, what owners report, and what it costs to keep.
AVOIR's read: a solid ownership case with specific caveats below.
Owners have filed 110 complaints with NHTSA about the 2002 Kia Optima, and it carries 3 recalls. These are owner allegations rather than confirmed defects, but the pattern of what people complain about is the most useful signal a used buyer has.
| Area | Complaints | Share |
|---|---|---|
| Air bags | 15 | 14% |
| Structure | 12 | 11% |
| Latches/locks/linkages | 9 | 8% |
| Electrical system | 8 | 7% |
| Suspension | 7 | 6% |
| Suspension | 7 | 6% |
| Service brakes | 6 | 5% |
| Engine and engine cooling | 6 | 5% |
| Visibility | 3 | 3% |
| Steering | 2 | 2% |
Verbatim from NHTSA complaint records, trimmed for length.
locked the car as most people do, then went to unlock the car heard it unlock but the door would not open. I could hear the door sound like it was locking/unlocking like it was stuck. I tried to climb through the passeng
NHTSA complaint: Electrical system
The contact owns a 2002 Kia Optima. The contact stated that after he replaced all four tires, the vehicle was taken to an independent mechanic for an alignment; however, the mechanic was unable to perform an alignment du
NHTSA complaint: Suspension
TL* THE CONTACT OWNS A 2002 KIA OPTIMA. THE CONTACT STATED THAT THERE WERE HOLES FROM CORROSION DUE TO SUB-FRAME RUST. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED WITH NEEDING THE SUB-FRAME TO
NHTSA complaint: Structure
OVER A WEEKS TIME,I NOTICED MY STEERING WHEEL WAS TURNED LIKE MAYBE I NEEDED AN ALIGNMENT AND IT STARTED PULLING TO THE LEFT SO BAD THAT I HAD TO FORCE THE STEERING WHEEL TO THE RIGHT SO I WOULDN'T WRECK INTO THE MEDIAN
NHTSA complaint: Suspension
TL* THE CONTACT OWNED A 2002 KIA OPTIMA. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE HYDROPLANED AND CRASHED INTO A TREE. THE AIR BAGS FAILED TO DEPLOY. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. THE VEHICL
NHTSA complaint: Air bags
TL* THE CONTACT OWNS A 2002 KIA OPTIMA. WHILE DRIVING APPROXIMATELY 10 MPH AND MAKING A LEFT TURN, THE FRONT DRIVER SIDE CONTROL ARM, TIE ROD, AND CV AXLE FRACTURED. THE VEHICLE WAS DIAGNOSED BY AN INDEPENDENT MECHANIC A
NHTSA complaint: Steering
MY 16 YEAR OLD JUST PURCHASED A 2002 KIA OPTIMA SEDAN ON SATURDAY 8/20/2016 FROM A USED CAR DEALERSHIP. VERY FIRST CAR, HIS OWN EARNED SAVINGS. UPON FINALIZING THE PAPERWORK, WE LITERALLY WALKED OUT THE DOOR & IMMEDIAT
NHTSA complaint: Electrical system
2002 KIA OPTIMA DRIVER DOOR WILL NOT UNLOCK WITH KEYLESS ENTRY OR FROM IN SIDE OF CAR ONLY AFTER LOCKING AND WAITING SEVERAL MINUTES TO HITTING UNLOCK ABOUT 20 TIMES TO GET THE DOOR TO UNLOCK HAVE BEEN LOCKED IN CAR AND
NHTSA complaint: Unknown or other
NHTSA lists 3 recall campaigns for the 2002 Kia Optima. Recalls are free to have fixed at a franchised dealer regardless of who owns the car now, but only if they were never done, so check the VIN of the specific car rather than trusting the model.
SOME PASSENGER VEHICLES MAY CONTAIN A FUEL TANK ASSEMBLY VALVE THAT MAY NOT CLOSE PROPERLY. IF A VEHICLE WITH A FUEL TANK ASSEMBLY VALVE THAT IS NOT PROPERLY CLOSED WERE TO ROLL OVER, FUEL SPILLAGE MAY OCCUR.
Risk: FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Fix: DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. OWNER NOTIFICATION BEGAN JUNE 25, 2004. OWNERS SHOULD CONTACT KIA AT 1-800-333-4542.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.5 AND 2.7 LITER V6 ENGINES, THE CRANKSHAFT POSITION SENSOR (CKP) CASES DID NOT MEET DIMENSIONAL SPECIFICATIONS.
Risk: INTERNAL GAPS WITHIN THE CASES ALLOWED EPOXY TO CONTACT THE PRINTED CIRCUIT BOARD, WHICH RESULTED IN CRACKING OF THE CIRCUIT BOARD CAPACITOR. A DAMAGED CKP CAPACITOR COULD RESULT IN ENGINE STALLING.
Fix: DEALERS WILL REPLACE THE CKP. OWNER NOTIFICATION BEGAN MARCH 28, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN
KIA MOTORS CORPORATION (KMC) IS RECALLING 36,538 MODEL YEAR 2001-2004 OPTIMA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO,
Risk: CORROSION OF THE FRONT SUBFRAME COULD LEAD TO SEPARATION, POSSIBLY RESULTING IN A VEHICLE CRASH.
Fix: KMC WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 15, 2009. OWNERS MAY CONTACT KIA'S CONSUMER ASSISTANCE CENTER AT 1-800-333-4542.
| Reliability raw | 82 | excellent |
|---|---|---|
| Longevity est. | 80 | excellent |
| Maintenance | 83 | excellent |
| Depreciation | 82 | excellent |
| Performance | 49 | below average |
| Efficiency | 38 | below average |
Percentile ranks against other midsize & large cars in the catalog.
What stands behind each score for this car:
Owners have filed 110 complaints with NHTSA for this model-year, and air bags is the most reported area with 15 of them (14%). There are 3 recalls on record. Check any specific car against its VIN before buying.
AVOIR scores its reliability 82/100 (excellent) from NHTSA recall campaigns and complaint density. That figure is a raw complaint count, not yet adjusted for sales volume, so a high-volume model scores worse than it deserves.
AVOIR scores its longevity 80/100, but that figure is an estimate built from the powertrain and the brand's record, not a measurement. A 2002 car has no 200,000-mile population to observe yet, so treat it as a prior rather than evidence.
AVOIR's read: worth a look, because a solid ownership case with specific caveats below. Its overall ownership score is 74/100. Condition, mileage and service history still matter more than any score, so get a pre-purchase inspection on the specific car.
Sources: NHTSA recalls and complaints, EPA fuel economy, IIHS awards, and live market listings. A score describes a model-year, not the individual car in front of you. Get a pre-purchase inspection.