Reliability, what owners report, and what it costs to keep.
AVOIR's read: a solid ownership case with specific caveats below.
Owners have filed 237 complaints with NHTSA about the 1996 Pontiac Sunfire, and it carries 10 recalls. These are owner allegations rather than confirmed defects, but the pattern of what people complain about is the most useful signal a used buyer has.
| Area | Complaints | Share |
|---|---|---|
| Engine and engine cooling | 34 | 14% |
| Air bags | 28 | 12% |
| Electrical system | 28 | 12% |
| Service brakes | 19 | 8% |
| Power train | 17 | 7% |
| Steering | 16 | 7% |
| Suspension | 8 | 3% |
| Structure | 8 | 3% |
| Visibility | 8 | 3% |
| Exterior lighting | 7 | 3% |
Verbatim from NHTSA complaint records, trimmed for length.
MY WRECK HAPPENED IN 2006. THE AIR BAG DEPLOYED AND CRUSHED MY FACE I HAD TO HAVE TITANIUM PLATES PUT IN MY FACE CRASHED MY LEGS BROKE MANY BONES.
NHTSA complaint: Air bags
TL* THE CONTACT OWNS A 1996 PONTIAC SUNFIRE. THE CONTACT STATED THAT WHILE PARKED, THE DRIVER'S SIDE AIR BAG DEPLOYED INADVERTENTLY. THE CONTACT THEN SHIFTED INTO REVERSE AND THE PASSENGER'S SIDE AIR BAG DEPLOYED INADVER
NHTSA complaint: Air bags
NUMEROUS FAILURES WITH MY CAR I AM ONLY LISTING THE ONES WHICH HAVE HAPPENED MORE THAN ONCE 1..TRANSMISSION FAILURE, TRANSMISSION FAILED 3 TIMES FIRST TIME WHILE TRAVELING 35MPH CAR CAME TO A DEAD STOP TIRES LOCKED UP,
NHTSA complaint: Service brakes
1996 PONTIAC SUNFIRE 2.2L. REAR RIGHT BRAKE LOCKS. CAUSES THE CAR TO SHUDDER AND DIFFICULT TO STOP. THIS ALSO CAUSES THE ABS AND BRAKE LIGHT TO ILLUMINATE ON THE DASH. BRAKES HAVE BEEN REPLACED. POSSIBLE FAILURE TO STOP
NHTSA complaint: Service brakes
TL* THE CONTACT OWNS A 1996 PONTIAC SUNFIRE. WHILE DRIVING 30 MPH THE DRIVER FRONTAL AIR BAG DEPLOYED WITHOUT WARRANT. AS A CONSEQUENCE SHE SUSTAINED BRUISES TO HER FACE AND SHOULDERS. SHE FILED REPORT NUMBER 717625697
NHTSA complaint: Air bags
FEBRUARY 2007 HAD VEHICLE SERVICED AND WAS TOLD REAR CALIPERS NEEDED REPLACEMENT. WORK WAS COMPLETED TOTALING $875. WITHIN A WEEK, THE BRAKES LOCKED, CAUSING THE VEHICLE TO SKID AND FAILURE TO STOP. NEARLY HIT A PEDEST
NHTSA complaint: Service brakes
FEBRUARY 25, 2009 - NOTICED WHEN USING THE TILT STEERING LEVER, THE STEERING COLUMN DID NOT LOCK AT CERTAIN LEVELS (LOWER POSITION). WITHIN A WEEK OF NOTICING THIS PROBLEM, I NOTICE THE STEERING COLUMN SEEMED LOOSE AND W
NHTSA complaint: Steering
TL*THE CONTACT OWNS A 1996 PONTIAC SUNFIRE. WITHIN A WEEK OF PURCHASING THE VEHICLE, IT BEGAN OVERHEATING. IN ADDITION, THE HEADLIGHTS WOULD REMAIN ILLUMINATED WHEN THE VEHICLE WAS TURNED OFF, WIPER FLUID WAS LEAKING,
NHTSA complaint: Engine and engine cooling
NHTSA lists 10 recall campaigns for the 1996 Pontiac Sunfire. Recalls are free to have fixed at a franchised dealer regardless of who owns the car now, but only if they were never done, so check the VIN of the specific car rather than trusting the model.
DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DU
Risk: IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.
Fix: DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Risk: IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED.
Fix: DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN MARCH 27, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN
CERTAIN DELPHI AFTERMARKET FUEL PUMP MODULES / MODULE RESERVOIR ASSEMBLIES (MRA) THAT WERE SOLD FOR USE ON THE ABOVE LISTED VEHICLES. DURING PRODUCTION THE MRAS VENT AND FUEL RETURN TUBES WERE REVERSED. THIS CONDITION CAN RESULT IN THE VEHICLE NOT RUNNING CORRECTLY (IDLE ROUGH AND/OR STALL) DUE TO
Risk: A STALLED VEHICLE CAN INCREASE THE RISK OF A VEHICLE CRASH. A FUEL LEAK CAN RESULT IN A FIRE.
Fix: DELPHI WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE MRAS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2007. OWNERS CAN CONTACT DELPHI AT 1-877-335-7443.
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE D
Risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Fix: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
| Reliability raw | 76 | good |
|---|---|---|
| Longevity est. | 76 | good |
| Maintenance | 89 | excellent |
| Depreciation | 60 | average |
| Performance | 47 | below average |
| Efficiency | 45 | below average |
Percentile ranks against other compact cars in the catalog.
What stands behind each score for this car:
Owners have filed 237 complaints with NHTSA for this model-year, and engine and engine cooling is the most reported area with 34 of them (14%). There are 10 recalls on record. Check any specific car against its VIN before buying.
AVOIR scores its reliability 76/100 (good) from NHTSA recall campaigns and complaint density. That figure is a raw complaint count, not yet adjusted for sales volume, so a high-volume model scores worse than it deserves.
AVOIR scores its longevity 76/100, but that figure is an estimate built from the powertrain and the brand's record, not a measurement. A 1996 car has no 200,000-mile population to observe yet, so treat it as a prior rather than evidence.
AVOIR's read: worth a look, because a solid ownership case with specific caveats below. Its overall ownership score is 70/100. Condition, mileage and service history still matter more than any score, so get a pre-purchase inspection on the specific car.
Sources: NHTSA recalls and complaints, EPA fuel economy, IIHS awards, and live market listings. A score describes a model-year, not the individual car in front of you. Get a pre-purchase inspection.